|
Titel:
|
|
Green power production by co-gasification of biomass and coal in coal-fired oxygen-blown entrained-flow based IGCC processes
|
|
|
|
Auteur(s):
|
|
|
|
|
|
Gepubliceerd door:
|
Publicatie datum:
|
|
ECN
|
1-11-1998
|
|
|
|
ECN publicatienummer:
|
Publicatie type:
|
|
ECN-RX--98-059
|
Artikel wetenschap tijdschrift
|
|
|
|
Aantal pagina's:
|
|
|
23
|
|
Gepubliceerd in: Extended ECN contribution to: Power-GEN International, Orlando, Forida, December 9-11, 1998 (), , , Vol., p.-.
Samenvatting:
The use of coal for large scale power production meets a growingenvironmental concern. In spite of the fact that clean coal conversion
technologies integrated with high-efficiency power production facilities,
such as IGCC, are developed, the aim for sustainable development strives for
a power production system based on renewable energy sources. One of the most
promising renewable energy sources that can be used in the Netherlands is
biomass, i.e. organic waste materials and/or energy crops. To accelerate the
introduction of this material, in a technical and economically acceptable
way, co-gasification with fossil fuels, in particular coal, in large scale
IGCC processes is considered. In this paper the technical feasibility,
economic profitability, and environmental acceptability of co-gasification of
biomass in coal-fired oxygen-blown entrained-flow based IGM is discussed.
Both a base-case coal-fired oxygen-blown entrained-flow based IGCC process -
showing strong resemblance to the Puertollano IGCC plant in Spain - and three
co-gasification concepts, viz.: (1) a concept with separate dry coal and
biomass feeding systems, (2) a concept with a combined dry
coal/biomass-derived pyrolysis char feeding system, and (3) a concept with
parallel biomass pre-treatment/gasification and combined fuel gas
clean-up/power production, were defined for further consideration. The
base-case system and the co-gasification concepts as well are modelled in the
flowsheet simulation package ASPEN". Steady-state integral system
calculations resulted in an overall net electrical plant efficiency for the
base-case system of 50. 1 %LHV (48.3 %HHV). Replacing about 10 % of the total
thermal plant input (coal) by biomass (willow) resulted in a decrease of the
overall net electrical plant efficiency of 1.4 to 2.1 %-points LHV, avoided
specific CO2 emissions of 40-49 g/kWhe, and total avoided CO2 emissions of
about 129 to 159 kt/a, all depending on the co-gasification concept
concerned. The net electrical efficiency of the biomass part amounts 28.4 to
35.8 %LHV, and is even significantly higher (> 45 %LHV) in 'fully' optimised
concepts presented. The costs per tonne CO2 avoided are calculated as 25 to
66 ECU/tonne, depending on the concept concerned, and will even become
negative in case of the proposed optimised concepts. The Simple Pay Back
Period for the necessary additional investment for these proposed optimised
concepts is 5-13 years, the Net Present Worth negative (discount rate: 7.5
%), and the Internal Rate of Return lower than (0 - 3 %) the market interest.
Co-gasification of Dutch organic waste materials, in the optimised
co-gasification concepts, is very promising from an economic point of view,
with a SPBP of the necessary additional investment of smaller than 4 years,
and an IRR of the necessary additional investment of 5 to 50%, depending on
the concept concerned. 18 refs.
Terug naar overzicht.